SIKA CORPORATION -- SIKAFLEX PRIMER, 429, 429  -- 8030-00N022234
<pre>=====================  Product Identification  =====================

Product ID:SIKAFLEX PRIMER, 429, 429
MSDS Date:12/20/1989
FSC:8030
NIIN:00N022234
=== Responsible Party ===
Company Name:SIKA CORPORATION
Address:201 POLITO AVENUE
City:LYNDHURST
State:NJ
ZIP:07071
Country:US
Info Phone Num:201-933-8800
Emergency Phone Num:800-424-9300(CHEMTREC)
Preparer's Name:SIL SANTANGELO
CAGE:OPMN0
=== Contractor Identification ===
Company Name:SIKA CORPORATION
Address:875 VALLEY BROOK AVENUE
City:LYNDHURST
State:NJ
ZIP:07071
Phone:800-424-9300
CAGE:OPMN0

=============  Composition/Information on Ingredients  =============

Ingred Name:METHYL ETHYL KETONE (2-BUTANONE) (MEK)  (SARA III)
CAS:78-93-3
RTECS #:EL6475000
OSHA PEL:200 PPM/300 STEL
ACGIH TLV:200 PPM/300STEL 9192
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS

Ingred Name:POLYURETHANE; (POLYESTER BASED)
OSHA PEL:5 MG/M3 (MFR)
ACGIH TLV:10 MG/M3 (MFR)

Ingred Name:P-TOLUENE SULFONYL ISOCYANATE
CAS:4083-64-1
OSHA PEL:0.02 PPM, C
ACGIH TLV:0.005 PPM

Ingred Name:TOLUENE  (SARA III)
CAS:108-88-3
RTECS #:XS5250000
OSHA PEL:200 PPM/150 STEL
ACGIH TLV:50 PPM; 9293
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS

=====================  Hazards Identification  =====================

LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES  Skin:YES  Ingestion:YES
Reports of Carcinogenicity:NTP:NO    IARC:NO	OSHA:NO
Health Hazards Acute and Chronic:INHAL:MAY CAUSE REVERSIBLE
    INFLAMMATORY EFT ON UPPER RESP SYS. MAY CAUSE EFT SUCH AS ANEST
    EFT/DROW/DIZZ/DECR IN MOTOR FUNC, CONVL, TREMORS, NARC OR
    BEHAVIORAL CHANGES. SKIN:MAY CAUSE REVERSIBLE INFLA MMATORY EFT ON
    SKIN/TISSUE @ SITE OF CONT. CAUSES AN ALLERGIC SENSIT IN
    SUBSTANTIAL PROPORTION OF (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ:HUMANS/ANIMALS IN NORM TISSUE AFTER
    RPTD EXPOS. MAY CAUSE DERM(SKIN RED/DRY/SCALING, ETC) FROM
    RPTD/PRLNG CONT. EYES:MAY CAUSE EFT TO EYE/VISUAL CAPACITY, SUCH AS
    DIPLOPIA, EYE GROUND, CATARA CTS, VISUAL DISTURB, CORNEA DAM, DAM
    TOOPTIC NERV/BLIND. INGEST:NOT NORMALLY INGESTED.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.

=======================  First Aid Measures  =======================

First Aid:INHAL: REMOVE TO FRESH AIR. IF BREATHING HAS STOPPED,
    INSTITUTE ARTF RESP. CONSULT PHYS. SKIN: WASH THOROUGHLY WITH SOAP
    AND WATER. REMOVE CONTAMINATED CLOTHING. IF SYMPTOMS PERSIST
    CONSULT PHYS. EYES : RINSE THOROUGHLY WITH WATER FOR AT LEAST 15
    MIN. CONSULT PHYS. INGEST: DILUTE WITH WATER. CONSULT PHYS.

=====================  Fire Fighting Measures  =====================

Flash Point Method:TOC
Flash Point:71.6F,22.0C
Extinguishing Media:FOAM/DRY CHEMICAL.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
    PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:IRRITATING AND/OR TOXIC GASES AND
    AEROSOLS FROM DECOMPOSITON/COMBUSTION PRODUCTS MAY BE PRESENT.

==================  Accidental Release Measures  ==================

Spill Release Procedures:WEAR APPROPRIATE PROECTIVE EQUIPMENT. CONTAIN
    SPILL AND COLLECT WITH ABSORBENT MATERIAL. USE NON-SPARKING TOOLS
    TO SHOVEL INTO CLOSABLE. CONTAINERS. VENTILATE AREA. ELIMINATE
    SOURCES OF IGNITION. AVOI D CONTACT.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

======================	Handling and Storage  ======================

Handling and Storage Precautions:STORE IN COOL DRY AREA AWAY FROM HEAT,
    SPARKS AND FLAME. KEEP CONTAINERS TIGHTLY CLOSED.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.

=============  Exposure Controls/Personal Protection  =============

Respiratory Protection:NIOSH/MSHA APPROVED ORGANIC VAPOR RESPIRATOR IF
    NECESSARY.
Ventilation:LOCAL EXHAUST HIGHLY RECOMMENDED. MECHANICAL EXHAUST HIGHLY
    RECOMMENDED.
Protective Gloves:CHEM RESISTANT RUBBER/PLASTIC GLOVES.
Eye Protection:CHEM WORK GOG & FULL LNGTH FSHLD 
Other Protective Equipment:OTHER PROTECTIVE CLOTHING.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.

==================  Physical/Chemical Properties  ==================

HCC:F3
Vapor Density:>AIR
Spec Gravity:0.93
Evaporation Rate &amp; Reference:SLOWER THAN ETHER
Appearance and Odor:CLEAR LIQUID, AROMATIC ODOR.
Percent Volatiles by Volume:70

=================  Stability and Reactivity Data  =================

Stability Indicator/Materials to Avoid:YES
WATER, ALCOHOLS, STRONG BASES AND OXIDIZING MATERIALS.
Stability Condition to Avoid:NONE KNOWN.
Hazardous Decomposition Products:OXIDES OF NITROGEN, CO, CO2,
    ISOCYANATES.

====================  Disposal Considerations  ====================

Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH FEDERAL, STATE AND
    LOCAL ENVIRONMENTAL REGULATIONS.

 Disclaimer (provided with this information by the compiling agencies):
 This information is formulated for use by elements of the Department
 of Defense.  The United States of America in no manner whatsoever,
 expressly or implied, warrants this information to be accurate and
 disclaims all liability for its use.  Any person utilizing this
 document should seek competent professional advice to verify and
 assume responsibility for the suitability of this information to their
 particular situation.